Tweet
Here goes, when trying to start the bike it likes to disingage and spin. So the question is can I rebuild it? where to get parts or do I need to replace it?
-
-
First, I would try flushing out the oil with some MMO/tranny fluid or seafoam, the starter clutch can get gummed up and slip. Don't run the engine under any load with the thinned oil though. If the starter clutch does end up needing to be replaced, it can be had from PartsNMore, but the engine cases will need to be split for replacement. The problem could also be running too thick of an oil or a bad starter connection possibly.Last edited by bikerphil; 07-25-2013, 09:42 PM.2H7 (79) owned since '89
3H3 owned since '06
"If it ain't broke, modify it"
☮ -
This is usually a symptom of very cold weather or very thick oil. I would take Bikerphil's advice.Skids (Sid Hansen)
Down to one 1978 E. Stock air box with K&N filter, 81H pipes and carbs, 8500 feet elevation.Comment
-
Synthetic oil has been known to do that too. Mine also slips a bit when I am due a new battery.....like now
Clean up the electrical connections and change the engine oil before ordering new parts 
( I think BikerPhil already said that 
)
Phil1981 XS1100 H Venturer ( Addie)
1983 XJ 650 Maxim
2004 Kawasaki Concours. ( Black Bear)Comment
-
Starter
It has brand new oil in it, with 0 miles on it. this the bike I converted into a trike.Comment
-
I guess the best thing I could advise is to re-check all electrical connections. Sorry I am not more help!2-79 XS1100 SF
2-78 XS1100 E Best bike Ever
80 XS 1100 SG Big bore kit but not fully running yet.
Couple of more parts bikes of which 2 more will live!Comment
-
Sorry, but it sounds like a starter clutch problem. That means engine removal and case splitting to repair.
Greg
Everybody is a genius. But if you judge a fish by its ability to climb a tree, it will live its whole life believing that it is stupid.”
― Albert Einstein
80 SG Ol' Okie;79 engine & carbs w/pods, 45 pilots, 140 mains, Custom Mac 4 into 2 exhaust, ACCT,XS850 final drive,110/90/19 front tire,TKat fork brace, XS750 140 MPH speedometer, Vetter IV fairing, aftermarket hard bags and trunk, LG high back seat, XJ rear shocks.
The list changes.
Comment
-
try the seafoam thing first. It may save you the hassle of major repairs. Really, the starter clutch slipping is VERY common in cold weather. It can sound a bit like a wounded duck (honking noise), just make a whirling sound, or make a clacking sound. All three of my xs11's have done this before without causing long term damage.Skids (Sid Hansen)
Down to one 1978 E. Stock air box with K&N filter, 81H pipes and carbs, 8500 feet elevation.Comment
-
It's July, almost August skids, I don't think there is a warmer month in the northern hemisphere.
Greg
Everybody is a genius. But if you judge a fish by its ability to climb a tree, it will live its whole life believing that it is stupid.”
― Albert Einstein
80 SG Ol' Okie;79 engine & carbs w/pods, 45 pilots, 140 mains, Custom Mac 4 into 2 exhaust, ACCT,XS850 final drive,110/90/19 front tire,TKat fork brace, XS750 140 MPH speedometer, Vetter IV fairing, aftermarket hard bags and trunk, LG high back seat, XJ rear shocks.
The list changes.Comment
-
Yes I know it is summer here. Hot as hell! But... I didn't check to see where his bike was located.Skids (Sid Hansen)
Down to one 1978 E. Stock air box with K&N filter, 81H pipes and carbs, 8500 feet elevation.Comment
Comment